Technical Information Wood Hard Primer

Technical Information Wood Hard Primer

DUPLI-COLOR Wood Hard Primer is a colourless, quick-drying, waterbased wood primer. It avoids that the subsequent paint coat sinks in.

For untreated wood, e.g. furniture, panels, wood casing. 

Quality and properties

  • adhesion promoting
  • quick-drying
  • avoids that the subsequent top coat sinks in
  • less bad odour
  • colourless
  • for inside

Physical and chemical data

  • Basis of the binder: Water-based
  • Colour: colourless
  • Smell: neutral
  • Degree of gloss (at measurement angle 60° acc. to DIN 67530):
    not relevant
  • Efficiency:
    Depending on thickness of the layer 750 ml are sufficient for 7,5 - 9 m²
  • Drying time (at 20°C, 65% relative air humidity):
    Surface-dry after approx. 2 hours
    Coatable after 8-12 hours
    The drying time depends on surrounding temperature, air humidity and absorpitivity of the wooden ground.
  • Cleaning of tools: immediately after use with warm water and if necessary with a cleanser
  • Storage stability:
    5 years if appropriate storage provided (=10°-25°C, relative air humidity of max. 60%) in the unopened original container. 
    Do not store below 5°C
  • Size: metal tins 750 ml 

Environment and labelling

Environmentally sound: European Aerosols is committed to apply formulations without restricted or critical ingredients and to achieve best possible performance. The caps and packagings are made of recyclable material.

Disposal: Only the completely emptied cans should be put into the recycling skip or appropriate container for reclaimable refuse. Cans which are not empty should be disposed off as "special refuse".

Marking/Labelling: All products made by  European Aerosols comply with the actual labelling regulations according to Preparation Guideline 1999/45/EG. All aerosols correspond to TRGS 200  and TRG 300 as well as to aerosol guideline 75/324/EWG in the actually valid version.

Using instructions

Before use, carefully read and observe the warning texts on the label!

Preparation of the ground:

In order to grant safe adhesion and to have a perfect coat of paint, prepare the ground as follo
wing:

  • The areas you want to paint should be clean, dry, dust- und fatfree, stable and bearing.
  • If intact, clean and sand pld paintings, otherwise remove with a paint remover.
  • Remove without residues flaking, not bearing old paintings.
  • The minimum working temperature for material and surroundings is +8°C.


Handling:

  • Before use, stir up well.
  • Dilute with max. 10 % water.
  • Brush (with a glaze brush for waterthinnable glazes) or spray airless (bring to spray viscosity)
  • New coating: prime rough wood undiluted with DUPLI-COLOR Aqua Wood Hard Primer. Apply 1-2 coats depending on demands and absorptivity of the subsoil, then overcoat with a coloured, pigmented wood glaze or a waterbased paint. Before every painting sand and clean the subsoil.

 

Tips for an optimal result:

  • Sand, clean and brush wood always in direction of the grain.
  • Especially after the first covering there might erect the wood fibers. They must be sanded before the next coating.
  • Care for a drying time of 8-10 hours between the single layers.
 

Order information

* kleuridentificatie niet mogelijk
De weergegeven kleuren wijken mogelijk af van de originele kleuren.
Om de productgegevens af te drukken, klik op "printing preview/further products".

There are no prdocuts to show.

Examples for use

Disclaimer of liability

This application-technological information is given to the best of our knowledge. The notes mentioned herein are, however, non-binding and do not exempt you from own tests to see whether the products supplied by us are suitable for your special application. The use and processing is beyond our control and therefore exclusively in the responsibility of the user. European Aerosols is let off the liability, unless the liability-based incident is caused by a fault incurred to European Aerosols.

As of March 14, 2018
This release replaces all eventually earlier issued versions.

NIEUWS

Vorig jaar vond de opening van ons Experience Center in Wolvega plaats. Deze nieuwe locatie aan de overkant van het hoofdkantoor in Nederland is de...

Meer lezen

IDEEËN

We hebben allemaal mooie oude meubelstukken liggen. En, het is het waard om eens een kijkje te nemen in de kasten van je grootouders, of ooms en...

Meer lezen

De presto reparatie box met PE-hars, verharder, glasvezel doek en glasvezel fleece biedt je alles wat je nodig hebt voor goedkope maar doeltreffende...

Meer lezen